Evaluación de la planta de tratamiento de aguas residuales de la parroquia Poatug, cantón Patate, provincia de Tungurahua
Date
2020
Authors
Journal Title
Journal ISSN
Volume Title
Publisher
Universidad Técnica de Ambato. Facultad de Ingeniería Civil y Mecánica, Carrera de Ingeniería Civil
Abstract
In the present experimental project, the Evaluation of the Wastewater Treatment Plant
(WWTP) located in Poatug Parish of the Patate City in Tungurahua province was
carried out with the objective of verify whether it is fulfilling the purpose for which it
was built properly.
The evaluation of the WWTP of the Poatug Parish began with a research of
information of the WWTP of this current state. The flow of residual water is
determined both at the entrance and at the exit of the WWTP and the important hours
in which greater and lesser amount of residual water enters the WWTP during the day.
In addition, a sample of the wastewater from the WWTP was conducted, which was
analyzed in a certify laboratory in order to determine the contaminant load that is
treated in the plant and compare with the parameters for wastewater discharges in
rivers established in the TULSMA 2015.
The current treatment process was evaluated (primary sedimentation, septic tank,
Anaerobic Upstream Flow Filter and sludge drying bed) used to remove contaminants
present in the incoming wastewater and it is found that it only removes approximately
40% of contaminants, which indicated that the WWTP is not working properly. On the
other hand, it was found that several of its hydraulic structures are not maintained with
the parameters established in the design manuals of the treatment plants.
Finally, it is proposed to incorporate a new treatment process (inlet box, screening,
sand trap, Anaerobic Upstream Flow Filter and sludge drying bed) so that the
wastewater treated in the WWTP theoretically removes about 90% of the contaminants
in an efficient way. On the other hand, an Operation and Maintenance Plan proposed
so that the WWTP will have a proper functioning.
Description
En el presente trabajo experimental se realizó la Evaluación de la Planta de
Tratamiento de Aguas Residuales (PTAR) existente en la parroquia Poatug del cantón
Patate en la provincia de Tungurahua con el objetivo de determinar sí está cumpliendo
adecuadamente el propósito para el cual fue construida.
La evaluación de la PTAR de la parroquia Poatug empezó con un levantamiento de
información de su estado actual. Se determinó el caudal de agua residual tanto al
ingreso como a la salida de la misma y se encontró las horas pico en las cuales ingresa
mayor y menor cantidad de agua residual a la PTAR durante el día. Además, se realizó
un muestreo del agua residual al ingreso y la salida de la PTAR, las mismas que fueron
analizadas en un laboratorio acreditado para determinar la carga contaminante que es
tratada en la planta y compararla con los parámetros para descargas de aguas residuales
en cuerpos de agua dulce establecidas en el TULSMA 2015.
Se evaluó el proceso de tratamiento actual (Desarenador, tanque séptico, Filtro
Anaerobio de Flujo Ascendente y lecho de secado de lodos) ocupados para remover
los contaminantes presentes en el agua residual que ingresa y se encontró que el mismo
solo remueve aproximadamente un 40% de los contaminantes, lo cual indicó que la
PTAR no está funcionando adecuadamente. Por otro lado, se encontró que varias de
sus estructuras hidráulicas no cumplen con los parámetros establecidos en los
manuales de diseño de las plantas de tratamiento.
Finalmente se propone incorporar un nuevo proceso de tratamiento (caja de entrada,
cribado, desarenador, FAFA y lecho de secado de lodos) para que el agua residual
tratada en la PTAR logre remover teóricamente alrededor del 90% de los
contaminantes de una forma eficiente. Por otro lado, se propone un Plan de Operación
y Mantenimiento para que la PTAR tenga un correcto funcionamiento.
Keywords
PLANTA DE TRATAMIENTO, AGUAS RESIDUALES, PTAR, DESARENADOR, TANQUE SÉPTICO, FILTRO ANAEROBIO, FLUJO ASCENDENTE, CRIBADO, SECADO DE LODOS, DISEÑO DE PROCESOS UNITARIOS PTAR